Заголовок статьи «Автономная система управления и аварийной защиты жидкостного ракетного двигателя»
Авторы И.С. Омельченко, Д.А. Бойцов
Аннотация В статье рассмотрена структурная реализация автономной системы управления режимами работы жидкостного ракетного двигателя. Приведена классификация отказов двигателя, а также рассмотрены возможные защитные операции. Описано функционирование предлагаемой системы управления, включающее в себя обработку внешних команд, данных с датчиков, формирование и обработку команд системы аварийной защиты, выдачу управляющих воздействий на двигатель, а также выдачу квитанций о состоянии двигателя. Рассмотренные принципы регулирования тяги жидкостного ракетного двигателя основаны на определении массовых расходов компонентов топлива в магистралях окислителя и горючего по показаниям датчиков температуры, датчиков давления и расходомеров. Приведён алгоритм работы системы аварийной защиты двигателя, включающий в себя операции регулирования и перевода двигателя в щадящий режим, аварийного выключения двигателя. Предлагаемый алгоритм основывается на анализе приращения ряда параметров, получаемых с датчиков, установленных в двигателе, а также на контроле выхода параметров за граничные значения. Описанная система обладает высоким быстродействием, что уменьшает суммарное время реагирования на отказ двигателя.
Ключевые слова система аварийной защиты, управление двигателем, отказ двигателя, массовый расход, режим работы двигателя
УДК 681.518.5
Выпуск «Проблемы машиностроения и автоматизации» №4 за 2014 год

 

Сведения об авторах

Омельченко Игорь Степанович — Д-р техн. наук, профессор, директор по информатизации, Открытое акционерное общество « Национальный институт авиационных технологий»,
Кировоградская ул., 3, Москва, 117587, Россия

Бойцов Дмитрий Алексеевич — Аспирант, кафедра «Автоматизированные системы обработки информации и управления», Московский государственный технологический университет «СТАНКИН»,
Данный адрес e-mail защищен от спам-ботов, Вам необходимо включить Javascript для его просмотра. Вадковский пер., д. 3а, Москва, 127055, Россия

 

Article title «Self-contained control and emergency protection system of the liquid-propellant rocket engine»
Authors I.S. Omel’chenko, D.A. Boytsov
Abstract This article is focused on the structural realization of self-contained system controlling the performance modes of liquid-propellant rocket engine. The classification of the engine failures is represented and possible protection operations are being analyzed in this document. The operation process of the proposed system is thoroughly described in the respective part of the article, including the processing of the external commands and detecting data, the formation and processing of the commands coming from the system of emergency protection, transmitting of the control inputs to the engine and issuing the reports on the state of the engine. The methods of engine driving force regulation system studied in this work rely on the estimation of the mass rate of fuel components in oxidizer and fuel ducts, which is performed corresponding to readings of the temperature sensors, pressure sensors and other measurement units. The operation algorithm of the system of engine emergency protection is being clarified in this article taking into account the engine control operations and the process of transition of the engine to the sparing engine operation mode or to the emergency engine cutoff mode. The proposed algorithm is based on the analysis of both the increment of parameters received from the sensors which are installed in the engine and the performance of the control of the parameters going up or under the threshold values. The described system appears to have rapid response time which leads to decrease total response time needed in case of the engine failure.
Keywords system of emergency protection, engine management, engine failure, mass rate, the operating mode of the engine
UDC 681.518.5
Issue «ENGINEERING AND AUTOMATION PROBLEMS» №4, 2014

 

Information about authors

Omel’chenko Igor’ Stepanovich — DSc, professor, director of informatization, Stock Company «National Institute of Aviation Technologies»,
3, Kirovogradskaya str., Moscow, 117587, Russia

Boytsov Dmitriy Alekseevich — Postgraduate of Stankin Moscow State Technological University, department "Automated Information processing and management",
Данный адрес e-mail защищен от спам-ботов, Вам необходимо включить Javascript для его просмотра. , 3а, Vadkovsky pereulok, Moscow, 127055, Russia